Having problems with your Air Conditioners ?

Tuneup kit for BDP A/C model 5690J042

\015 My BDP, 5-ton, a/c unit was installed in 1985 and the model # 5690J042 is shown on the plate. I need to tune it up,(tuneup kit to replace Starting & running capacitors, contactors, etc) but I can not find component part numbers, equivalents components or service manual. Did Carrier change its model numbering system? Can you help?\015

Answers :

Hi, most of the time generic parts are used to replace bad ones. The voltages and microfarads or UF is what's important on the capacitors and the amperage and control voltage on the contactor. Your unit will not run better with new parts and I suggest your time and money be used to clean and check your unit instead of "tuning it up" with new parts. If the capacitors are swelled or leaking oil they need replaced. If the contacts are pitted or burned, they need replaced. The condensing unit will need cleaned from the inside out. Remove the fan assembly and spray from the inside out on each of the condensing coils to remove the debris stuck inside the fins. If there are oil ports on your fan motor, add about 4 drops of oil into both of them. The same on your inside fan motor. If it has a fan belt inside check it to make sure it isn't worn too badly. Adjust it if needed to give about 3 inches of play. Too tight will make your bearings go bad. Oil your bearings if the fan has then and they have oil ports. Check the evaporator inside to see if it has a blanket of fuzz on the side where the air enters it. It can be removed with a credit card when wet. Scrape along with the fins if it needs cleaned. With the unit running and the inside of the house fairly comfortable the large refrigerant line outside should sweat all the way up to the compressor but the compressor should remain fairly dry. If it does, you have a good refrigerant charge. With this cleaning and oiling your unit should work more efficiently and be ready for another year. NOTE: The heating/air-conditioning companies usually run a special on seasonal checkups. If you have one come out, Have them do all the above plus get your furnace cleaned and ready. If you want more information on the furnace, please let me know what kind it is and I will try to help.\015\012If this solution does not rate at least (ALMOST THERE) Please do not rate.\015\012Thank You.\015\012kstfas
If indeed it is a Carrier 38CKC042 model and 208/230 single phase, you need part number HN51KC024 for your contactor and the Dual Capacitor is P291-4054RS. Your unit may have 3 more numbers on the manufacturers plate that will be required to verify these parts.

Repair Help & Product Troubleshooting for Air Conditioners
You need a second opinion or clarification ? ask it in the comment box OR you can Ask Your Own Question

Tips for a great answer:

  • Please provide as much detail as possible as this will allow our members to better understand and respond to your Comment
  • If you need clarification, ask it in the comment box
  • It's 100% free, no registration required

Suggested Questions/Answers :

It is recommended you read all this kind of situations

Tuneup kit for BDP A/C model 5690J042


Hi, most of the time generic parts are used to replace bad ones. The voltages and microfarads or UF is what's important on the capacitors and the amperage and control voltage on the contactor. Your unit will not run better with new parts and I sugges ... Carrier 38CKC042 Air Conditioner

I HAVE A INTERTHERM WOOD BURNING FIREPLACE. I AM LOOKING FOR A FORCED AIR BLOWER KIT. THE MODEL # IS BM36HC-BL. I AM LOOKING FOR THE FAN KIT THAT BLOWS OUT THE HOT AIR. THE PART # FOR THE FAN KIT IS 36L32, OR A FAN KIT THAT WOULD BE COMPATABLE TO MINE. WHERE CAN THIS BE PURCHASED. THANK YOU


... Intertherm Air Conditioners

New rheem model rsnlco60jk with model rxqj-a15j heater kit will not heat


... Protech Rheem/RXQJ-A15J - Heater Kit - Rheem/Ruud/ A complete

Window kit Hello, As posted by others, the window kit is a bit difficult. If you size it to fit the window, you have to cover the holes for the exhaust. Someone said they cut the plastic. Is that what you are supposed to do? It is heavy plastic. What do you cut it with? The directions do not make sense. HELP! Our manual says Models DPAC10061 & DPAC120068 Thank you!


Hi, you do have to cut the plastic strip to fit - I spent an hour trying to reach "tech support" only to be told to cut it..... ... Danby DPAC10031 Air Conditioner

Installed model 48203A876 s/n 061007181 ac in my enclosed trailer. added 9330A6151 heat strip converson kit. The kit came with a new thermostat, wiring diagrham, thermostat button and main control button that is the same as the one on the unit. Neither has low heat on it as an option. Is my original unit ready fot the heat strip or should I have to replace the thermostat, button, or anything?


... Coleman Mach III Air Conditioner

I ordered a new fan motor kit for Model #600315.321 the instructions are not clear on how to install the electrical, the kit came with a new capacator but no information about removing the old capacator if i add the new capacator there will be 3 capactors on the unit? do you have a wire diagram for this problem


The new capacitor is to take place of the old one feeding the motor. Other than that, it should be a simple in and out procedure. white, black, and red wires are typically hot legs and the brown wires are for the capacitor. ... Air Conditioners

We have a model ubha-17j10nuca evaporator .we are installing a 12 seer condensor unit and they sent a KIT RXCTCHKM3306 TO CHANGE PISTON FEED TO A EXPANSION VALVE TO MAKE OLD 10 SEER UPGRADE TO 12 SEER . NEED THE PIPING DIAGRAM TO INSTALL KIT.


Liquid line to inlet of txv. outlet of txv to inlet of evaporator. outlet of evaporator to suction line. does txv have a equializing line? strap bulb to outlet of evaporator, at either 11 oclock or one oclock and insulate bulb. ... Ruud Air Conditioners

Window Kit for Fedders Portable A/C Model:nmpeb08f2a


... Maytag NMPEB08F2A Air Conditioner

Missing vent kit for portable air conditioner model CPF10XCL-LW


... Air Conditioners

Need window exhaust kit for model PAC13KR-342R, can you help???


... Air Conditioners

I would like to purchase amcor portable A/C window venting kit - model # AL10000E


... Amcor Air Conditioners

I would like to purchase a amcor portable A/C window venting kit - model # AL10000E


... Amcor Air Conditioners

Hi we have a gas heater that was set up for L.P gas and we have Natulal Gas I got a conversion kit from Grainger sins this unit is Dayton model #4LX61 heater with a honywell smart valve part # sv9640m4132 but I still canot get it to work


What is it that you can't get to work? pilot light....gas flame (sorry, not enough informations) ... Honeywell Air Conditioners

Need a window adaptor kit for exhaust hose for Everstar model MPA-08CR AC. Any ideas?


MIDEA \015\012\015\012 ADAPTER Product Details: (sku:211250112)http://www.supportuscenter.com/product.asp?specific=242 ... Air Conditioners

I need to know what are the specs for (BDP Co.) Carrier Corp. Model 5410 1024, it is an old High Efficiency Heat Pump; maybe from the early 80's, I need to replace it and need to buy one of the same capacity


2 ton ... Air Conditioners

What is the seer rating on my bdp company division of carrier air conditioner model #397haw036080 serial # 2884c96839?


... Amana Comfort Zone 12M32PBEH Air Conditioner

I bought a Hunter light kit (model 28568) and it came with no instructions. I need to know how to install it in a Hunter ceiling fan (CP9110)?


... Air Conditioners

Manual for bdp model 361aan048125 furnace - Air Conditioners


... Air Conditioners

My compressor works itermittantly. I was holding suction line to see if it felt cold. It felt kinda cool. Then all of a sudden it went COLD. A minute or two later it was kinda cool again. Could my compressor motor be going off and on. If so, could a hard start kit help? Motor is cscr. Its on a Goodman 2 ton, r22 unit. Model ck24-1


A hard start kit always helps. Take a reading inside. Temp at the return air and temp at the closest grille. Subtract and that temp should be between 19 to 23 degrees. If not you have other problems. Contact service tech for free estimate. Possibly a ... Air Conditioners

I bought an Everstar Portable Air Conditioner Model # MPM1-10CR-BB6. It lacks a manual, the drain kit and the attachment to exhaust the hot air outside. Where can I get parts and a manual?


I have the window rig and am not using it.email me and I'll sell it cheap. ... Air Conditioners

Looking for shroud for Duo_Therm Model 57915.622 and soft start kit.


There is a company out of Haltom City, Texas called United RV. They sell parts for RV's. I would give them a call and see if they could ship you what you need. Good luck! ... Dometic Rooftop RV Air Conditioner

How do I get a replacement window kit frame for Model #DWC-055RL?


... Daewoo DWC-056CL Air Conditioner

BDP furnace + model 585A030080YACR


Sounds like your indoor fan motor is not working, check either the cap or the indoor fan motor it's self. ... Carrier Air Conditioners

I have a Goodman Model number AR24-1 unit and the blower moter will not start with it turned on to fan or cool or heat. I have checked the thermostat and the unit runs outside. Just no blower. Can I jump the blower motor as I replaced the capacitor today. Hear are some numbers that may help. Part Number #15212-50 Volt 208/240 Amp 1.5 HP 1/5 No heat Kit It has a Goodman switch board # B1370735 that I can check with my meter if needed. I have checked the thermostat in the attic also. Seems like


... Air Conditioners

New Hampton Bay Model 640-657 Classic Collection Burgess 54" Celing Fan with Remote. I have had installed by electrician ,also re checked by different electrician. Both have charged me and told me it is wired correctly. Comes on some time by itsself and then light will not go out. I have replaced the battery 3 times with no help. I have wired into a wall switch . prior to the Fan. Could use some help. Is there a kit I can wire without the Remote. Fan is less than 3 weeks old. Getty costly to k


... Air Conditioners

A detailed question is important to get you a relevant answers

  • Start your question with What, Why, How, When, etc. and end with a "?"
  • Be clear and specific
all rights reserved to the respective owners || www.ad-trader.net || Terms of Use || Contact || Privacy Policy
Load time: 0.0508 seconds